Kia Sportage: Troubleshooting

Third generation SL (2010â€“2016) / Kia Sportage SL Service & Repair Manual / Body (Interior and Exterior) / General Information / Troubleshooting

Troubleshooting

Symptom	Suspect Area	Remedy
Water leaks from panoramaroof	Deteriorated roof lid weatherstrip	Replace
Water leaks from panoramaroof	Excessive roof lid-to-body clearance and Improperly fitted weatherstrip	Adjust
Wind noise around sunroof	Loose or deformed deflector, gapsIn body work	Retighten adjust or replace
Noise heard when opening/ closing panoramaroof	Foreign particles lodged in guide rail	Check drive cable and guide rails for foreign particles
Noise heard when opening/ closing panoramaroof	Loose guide rails and lid	Retighten
Motor runs but sunroof does not move or moves only partially	Foreign particles lodged in guide rail	Adjust or replace
	Incorrect engagement of motor pinion with drive cable
	Decrease in motor`s clutch slipping force
	Increased sunroof sliding resistance or interference of sunroof with drive cables, weatherstrip, etc. due to maladjustment of sunroof
Noise in motor (clutch slipping noise from motor when sunroof is fully opened or closed is not an unusual noise	Incorrect engagement of motor pinion with drive cable	Check pinion installation and retighten motor
	Worn out or damaged motor pinion bearing	Replace motor assembly
	Worn out or deformed drive cable	Replace
Door glass fails to operate Up and Down	Incorrect window glass installation	Adjust position
Door glass fails to operate Up and Down	Damaged or faulty regulator arm or regulator	Correct or replace
Door does not open or close completely	Incorrect door installation	Adjust position
	Defective door check assembly	Correct or replace
	Door hinge requires grease	Apply grease
Hood does not open or close completely	Striker and latch not properly aligned	Adjust
	Incorrectly installed hood	Adjust
	Incorrect hood bumper height	Adjust
Water leak through windshield and rear window	Defective seal	Fill with sealant
Water leak through windshield and rear window	Defective flange	Correct

Special Service Tools

Special Tools Tool (Number and name)IllustrationUse09793-21000Door hinge adjusting wrenchAdjustment, removal and installation of the door hinge09800-21000Ornament removerTrim removal09853-31000H ...

Other Information:

Components and Components Location
Component Location (1) 1. Buzzer2. Smart key unit3. RF receiver4. Interior antenna 15. Interior antenna 26. Interior antenna 37. Bumper antenna Component Location (2) 1. Door outside hand ...

KEY OUT indicator
When the ENGINE START/STOP button is in the ACC or ON position, if any door is open, the system checks for the smart key. If the smart key is not in the vehicle, the indicator will blink, and if ...

Kia Sportage: Troubleshooting

Special Service Tools

Body Dimensions

Other Information:

Categories